granite slurry as partial replacement of fine aggregate



Popular Searches

Geo Polymer Concrete with the Replacement of Granite ,

granite fines content was the optimum value for improved structural performance Kanmalai Williams C et al 2008 examined the performance of concrete made with the granite powder as fine aggregate Sand was replaced with granite powder in steps of 0, 25, 50, 75 and 100 and cement was replaced with 75 Silica fume, 10 fly ash and 10 slag...

Project on Partial Replacement of Cement with Marble Powder

In this project our main objective is to study the influence of partial replacement of cement with marble powder , and to compare it with the compressive and tensile strength of ordinary M20 concrete We are also trying to find the percentage of marble powder replaced in concrete that makes the strength of the concrete maximum...

Use of Crushed Granite Fine as Replacement to River Sand ,

Use of Crushed Granite Fine as Replacement to River Sand in Concrete Production , than the cost of N 18,399 per cubic metre of concrete required to produce the same grade of concrete using crushed granite as coarse aggregate and river sand as fine aggregate Based on the above economic analysis 20 crushed granite fine is recommended for use ....

AN EXPERIMENAL STUDY ON PARTIAL REPLACEMENT OF ,

AN EXPERIMENAL STUDY ON PARTIAL REPLACEMENT OF FINE AGGREGATE WITH GRANITE SLURRY AND CEMENT WITH GGBS Kavya B R1, Chandrashekar A R2 1Post Graduate in Structural Engineering, BIET College, Davanagere-577004, India 2Asst Professor, M Tech Structural Engineering, BIET College, Davanagere...

PDF EXPERIMENTAL INVESTIGATION ON CONCRETE WITH ,

River sand is nowadays a scarce commodity and exploring alternativ So an attempt is made on replacing the granite sludge powder as a partial replacement for fine aggregate in concrete The study is carried out with 20, 40, 60 and 80 percentage...

Optimization of Granite Powder used as Partial Replacement ,

Partial replacement of cement and usual fine aggregates with varying percentage of marble powder 0 , 5 , 10 , 15 , and 20 and marble granules revealed that increased Waste Marble Powder WMP or Waste Marble Granule WMG resulted in increase in workability and compressive strength of mortar concrete 8...

Strength Properties of Concrete with Partial Replacement ,

performance concrete made with granite powder as fine aggregate and partial replacement of cement with 75 silica fume, 10 fly ash and 10 slag subjected to water curing is conducted for finding the mechanical properties such as compressive strength, split tensile strength, modulus of...

Partial Replacement of Cement With Marble Powder in Concrete

Fine aggregate M- sand was used as fine aggregate The specific gravity and fineness modulus was 255 and 293 respectively Coarse aggregate The 20mm size aggregates-The coarse aggregates with size of 20mm were tested and the specific gravity value ,...

INVESTIGATION ON GEOPOLYMER CONCRETE USING ,

Granite Slurry powder as replacement of fine aggregate for 0 , 20 , 40 Compressive strength test was conducted on the cubical specimens for all the mixes after 7, 28, and 90 days of curing as per IS 516 7 Three cubical specimens of size 150 mm x 150 mm x 150 mm were cast and tested for each age and each mix Splitting tensile strength STS ....

REPLACEMENT OF FINE AGGREGATE WITH JAROFIX IN ,

Ramalingam 19 studied on partial replacement of fine aggregate by granite powder in concrete and found that 40 of the fine aggregate can be replaced with granite powder Radhika and Bramhini 17 have studied the utilization of construction and demolition waste for the replacement of fine aggregate in ,...

Experimental Analysis on Partial Replacement of Fine ,

Upadhyaya S, Nanda B, Panigrahi R 2019 Experimental Analysis on Partial Replacement of Fine Aggregate by Granite Dust in Concrete In Das B, Neithalath N eds Sustainable Construction and Building Materials Lecture Notes in Civil Engineering, vol ,...

A study of the chemical effect of marble and granite ,

The marble and granite industries in Egypt produce a vast amount of by-product slurry waste that could be used in green mortar production suitable for construction purpos This research highlights the effect of the chemical constituents of marble and granite waste powders on the compressive strength of the green concrete produced A chemical analysis of the constituents of granite and marble ....

PDF Experimental Study on Partial Replacement of Fine ,

Granite fines which are the by-product produced in granite factories while cutting huge granite rocks to the desired shapes, while cutting the granite rocks, the powder produced is carried by the water and this water is stored in tanks After drained...

Recycled aggregate concrete produced with red granite dust ,

The coarse aggregates used were a nominal 20 mm down crushed granite natural aggregate for the control mixes and a similarly graded recycled, crushed, screened and washed aggregate with approximately 66 impurities timber, metal, glass, paper, rubber and mortar The fine aggregate was a natural medium sand...

Review Utilization of Waste Foundry Sand and Granite ,

partial replacement of fine aggregate in conventional concrete Granite Slurry GS is also industrial by products generated from the granite polishing and milling industries in powder form These by-products are left largely unused and are hazardous material to human health Construction industry in...

Investigation on Strength Properties of Concrete with ,

fine aggregate sand and cement were partially replaced with Granite powder and marble powder The replacement is done by 5 , 10 , 15 , 20 , 25 of cement by marble powder and 5 , 10 , 15 , 20 , 25 of fine aggregate by granite powder to evaluate the effect of presence of these replacement materials on the strength of specimens...

Vol 5, Issue 8, August 2016 Experimental Study on ,

Granite Slurry powder as replacement of fine aggregate for 0 , 20 , 40 and 60 Compressive strength test was conducted on the cubical specimens for all the mixes after 7, 28, and 90 days of curing as per IS 516 7 Three cubical specimens of size 150 mm x 150 mm x 150 mm were cast and tested for each age and each mix Splitting...

EXPERMENAL STUDIES ON M20 GRADE CONCRETE BY ,

Concrete is prepared with granite fines as a replacement of fine aggregate in 6 different proportions namely 0 , 10 , 20 , 30 , 40 and 50 The test results indicate that granite powder as replacement fine aggregate has beneficial effect on the mechanical durability properties such as compressive strength, split tensile strength and...

PDF UTILIZATION OF GRANITE CUTTING WASTE IN CONCRETE ,

The main objective of this study is to experimentally investigate the suitability of granite powder GP waste as a substitute material for fine/natural aggregate in concrete production...

Experimental study of concrete made with granite and iron ,

The concrete mix made using granite powder GP and iron powder IP as partial replacement of sand showed good workability and fluidity similar to normal concrete mix 2 The compressive strength of concrete increased with the addition of granite powder GP as partial replacement of sand...

An Experimental study on partial replacement for coarse ,

An Experimental study on partial replacement for coarse aggregate by Granite Waste RSiva Kumar,HMohammed yousuff,MHaripriya Third Year Department Of Civil Engineering SNS College of Engineering Abstract In developing countries where concrete is widely used, the high and steadily increasing cost of...

Strength and Durability Properties of Granite Powder Concrete

made with granite powder as fine aggregate The percentage of granite powder added by weight a range viz 0, 25, 50, 75 and 100 as a replacement of sand used in concrete and cement was replaced with 75 Silica fume, 10 fly ash, 10 slag and 1 super plastiziser The effects of curing temperature at 32 Sand 040 water -to-binder w/b ratio for 1....

Strength and Durability Properties of Granite Powder Concrete

The most commonly used fine aggregate across world is river sand River sand is expensive due to excessive cost of transportation from natural sourc Also large scale depletion of the source creates environmental problems As environmental, transportation and other constraints make the availability and use of river sand less attractive A substitute or replacement product for concrete ....

Utilization of Granite Slurry Waste in Concrete A Review ,

Findings It is shown that the granite slurry waste reduces the workability whereas compressive strength of granite concrete is improved when fine aggregate or cement is partially replaced...